AD 98-13-17

AD Final Rules - DRS_98-13-17.html
Copy URL
Print/Save as PDF
Document Versions
 Feedback
Details
AD Number:
98-13-17
Document Type:
AD Final Rules
Docket Number:
98-NM-66-AD
Subject Heading:
Airworthiness Directives; EMPRESA BRASILEIRA DE AERONAUTICA S.A. (EMBRAER) Model EMB-145 Series Airplanes
Subject:
Windshield Heating System
Status:
Current
Citation:
This information is not available.
Citation Publish Date:
Effective Date:
07/30/1998
Make:
Embraer S.A.
Model:
EMB-145 | EMB-145ER | EMB-145LR | EMB-145MR
Product Type:
Aircraft
Product Subtype:
Large Airplane
Affected AD:
Superseded AD:
Affected By:
Superseded By:
Service/Office:
Office of Primary Responsibility:
CFR Part Reference:
Part 39 [63 FR 34559 NO. 122 06/25/98]
Comments:
AIRWORTHINESS DIRECTIVES FINAL RULES: 98-13-17
CITATION:   This information is not available.

PAGE NUMBER:  

DOCKET NUMBER:   98-NM-66-AD

AMENDMENT:   39-10605

AD NUMBER:   98-13-17

SUBJECT HEADING:   Airworthiness Directives; EMPRESA BRASILEIRA DE AERONAUTICA S.A. (EMBRAER) Model EMB-145 Series Airplanes

ACTION:   Final rule

SUMMARY:   This amendment adopts a new airworthiness directive (AD), applicable to certain EMBRAER EMB-145 series airplanes, that requires modification of the windshield heating system in the flight compartment. This amendment is prompted by reports of overheating and delamination of the windshield because the windshield heating system failed to shut off during flight. The action specified by this AD is intended to prevent failure of the windshield heating system, which could result in reduced pilot visibility, structural degradation of the windshield, and depressurization of the airplane during flight.

DATES:   Effective July 30, 1998.

ADDRESSES:   The service information referenced in this AD may be obtained from Empresa Brasileira de Aeronautica S.A. (EMBRAER), P.O. Box 343 - CEP 12.225, Sao Jose dos Campos - SP, Brazil. This information may be examined at the Federal Aviation Administration (FAA), Transport Airplane Directorate, Rules Docket, 1601 Lind Avenue, SW., Renton, Washington; or at the FAA, Small Airplane Directorate, Atlanta Aircraft Certification Office, One Crown Center, 1895 Phoenix Boulevard, suite 450, Atlanta, Georgia; or at the Office of the Federal Register, 800 North Capitol Street, NW., suite 700, Washington, DC.

FOR FURTHER INFORMATION CONTACT:   John W. McGraw, Aerospace Engineer, Systems and Flight Test Branch, ACE-116A, FAA, Small Airplane Directorate, Atlanta Aircraft Certification Office, One Crown Center, 1895 Phoenix Boulevard, suite 450, Atlanta, Georgia 30337-2748; telephone (770) 703-6098; fax (770) 703-6097.

SUPPLEMENTARY INFORMATION:  
A proposal to amend part 39 of the Federal Aviation Regulations (14 CFR part 39) to include an airworthiness directive (AD) that is applicable to certain EMBRAER EMB-145 series airplanes was published in the Federal Register on April 21, 1998 (63 FR 19677). That action proposed to require modification of the windshield heating system in the flight compartment.

Comments
Interested persons have been afforded an opportunity to participate in the making of this amendment. Due consideration has been given to the single comment received.

The commenter supports the proposed rule.

Conclusion
After careful review of the available data, including the comment noted above, the FAA has determined that air safety and the public interest require the adoption of the rule as proposed.

Cost Impact
The FAA estimates that 17 airplanes of U.S. registry will be affected by this AD. It will take approximately 12 work hours per airplane to accomplish the required modification, at an average labor rate of $60 per work hour. Required parts will be supplied by the manufacturer at no cost to the operators. Based on these figures, the cost impact of the modification required by this AD on U.S. operators is estimated to be $12,240, or $720 per airplane.

The cost impact figure discussed above is based on assumptions that no operator has yet accomplished any of the requirements of this AD action, and that no operator would accomplish those actions in the future if this AD were not adopted.

Regulatory Impact
The regulations adopted herein will not have substantial direct effects on the States, on the relationship between the national government and the States, or on the distribution of power and responsibilities among the various levels of government. Therefore, in accordance with Executive Order 12612, it is determined that this final rule does not have sufficient federalism implications to warrant the preparation of a Federalism Assessment.

For the reasons discussed above, I certify that this action (1) is not a "significant regulatory action" under Executive Order 12866; (2) is not a "significant rule" under DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979); and (3) will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act. A final evaluation has been prepared for this action and it is contained in the Rules Docket. A copy of it may be obtained from the Rules Docket at the location provided under the caption "ADDRESSES."

List of Subjects in 14 CFR Part 39
Air transportation, Aircraft, Aviation safety, Incorporation by reference, Safety.

Adoption of the Amendment
Accordingly, pursuant to the authority delegated to me by the Administrator, the Federal Aviation Administration amends part 39 of the Federal Aviation Regulations (14 CFR part 39) as follows:

PART 39 - AIRWORTHINESS DIRECTIVES
1. The authority citation for part 39 continues to read as follows:
Authority: 49 U.S.C. 106(g), 40113, 44701.

§ 39.13 [Amended]
2. Section 39.13 is amended by adding the following new airworthiness directive:

REGULATORY TEXT:  
98-13-17 EMPRESA BRASILEIRA DE AERONAUTICA S.A. (EMBRAER): Amendment 39-10605. Docket 98-NM-66-AD.
Applicability: Model EMB-145 series airplanes, serial numbers 145004 through 145029 inclusive; certificated in any category.

NOTE 1: This AD applies to each airplane identified in the preceding applicability provision, regardless of whether it has been modified, altered, or repaired in the area subject to the requirements of this AD. For airplanes that have been modified, altered, or repaired so that the performance of the requirements of this AD is affected, the owner/operator must request approval for an alternative method of compliance in accordance with paragraph (b) of this AD. The request should include an assessment of the effect of the modification, alteration, or repair on the unsafe condition addressed by this AD; and, if the unsafe condition has not been eliminated, the request should include specific proposed actions to address it.

Compliance: Required as indicated, unless accomplished previously.

To prevent failure of the windshield heating system, which could result in reduced pilot visibility, structural degradation of the windshield, and depressurization of the airplane during flight, accomplish the following:

(a) Within 60 days after the effective date of this AD, modify the windshield heating system in accordance with EMBRAER Service Bulletin 145-30-0008, dated November 10, 1997.

(b) An alternative method of compliance or adjustment of the compliance time that provides an acceptable level of safety may be used if approved by the Manager, Atlanta Aircraft Certification Office (ACO), FAA, Small Airplane Directorate. Operators shall submit their requests through an appropriate FAA Principal Maintenance Inspector, who may add comments and then send it to the Manager, Atlanta ACO.

NOTE 2: Information concerning the existence of approved alternative methods of compliance with this AD, if any, may be obtained from the Atlanta ACO.

(c) Special flight permits may be issued in accordance with sections 21.197 and 21.199 of the Federal Aviation Regulations (14 CFR 21.197 and 21.199) to operate the airplane to a location where the requirements of this AD can be accomplished.

(d) The modification shall be done in accordance with EMBRAER Service Bulletin 145-30- 0008, dated November 10, 1997. This incorporation by reference was approved by the Director of the Federal Register in accordance with 5 U.S.C. 552(a) and 1 CFR part 51. Copies may be obtained from Empresa Brasileira de Aeronautica S.A. (EMBRAER), P.O. Box 343 - CEP 12.225, Sao Jose dos Campos - SP, Brazil. Copies may be inspected at the FAA, Transport Airplane Directorate, 1601 Lind Avenue, SW., Renton, Washington; or at the FAA, Small Airplane Directorate, Atlanta Aircraft Certification Office, One Crown Center, 1895 Phoenix Boulevard, suite 450, Atlanta, Georgia; or at the Office of the Federal Register, 800 North Capitol Street, NW., suite 700, Washington, DC.

(e) This amendment becomes effective on July 30, 1998.

FOOTER: