AD 2006-13-10

[Federal Register Volume 71, Number 122 (Monday, June 26, 2006)]
[Rules and Regulations]
[Pages 36185-36187]
From the Federal Register Online via the Government Publishing Office [<a href="http://www.gpo.gov">www.gpo.gov</a>]
[FR Doc No: 06-5586]



========================================================================
Rules and Regulations
                                                Federal Register
________________________________________________________________________

This section of the FEDERAL REGISTER contains regulatory documents 
having general applicability and legal effect, most of which are keyed 
to and codified in the Code of Federal Regulations, which is published 
under 50 titles pursuant to 44 U.S.C. 1510.

The Code of Federal Regulations is sold by the Superintendent of Documents. 
Prices of new books are listed in the first FEDERAL REGISTER issue of each 
week.

========================================================================


Federal Register / Vol. 71, No. 122 / Monday, June 26, 2006 / Rules 
and Regulations

[[Page 36185]]



DEPARTMENT OF TRANSPORTATION

Federal Aviation Administration

14 CFR Part 39

[Docket No. FAA-2005-23319; Directorate Identifier 2005-CE-52-AD; 
Amendment 39-14663; AD 2006-13-10]
RIN 2120-AA64


Airworthiness Directives; Raytheon Aircraft Company 65, 90, 99, 
and 100 Series Airplanes

AGENCY: Federal Aviation Administration (FAA), Department of 
Transportation (DOT).

ACTION: Final rule.

-----------------------------------------------------------------------

SUMMARY: We are adopting a new airworthiness directive (AD) that 
supersedes AD 92-07-05, which applies to certain Raytheon Aircraft 
Company (Raytheon) (formerly Beech) 65, 90, 99, and 100 series 
airplanes. AD 92-07-05 currently requires you to inspect the rudder 
trim tab for proper moisture drainage provisions, and if the correct 
drainage provisions do not exist, before further flight, modify the 
rudder trim tab. This AD results from receiving and evaluating new 
service information that requires the actions of AD 92-07-05 for the 
added serial numbers LJ-1281 through LJ-1732 for the Model C90A 
airplanes. This AD retains all the actions of AD 92-07-05 and adds 
serial numbers LJ-1281 through LJ-1732 for the Model C90A airplanes in 
the applicability section. We are issuing this AD to prevent water 
accumulation in the rudder trim tab, which could result in a change in 
the mass properties and possibly a lower flutter speed of the airplane. 
A lower airplane flutter speed could result in failure and loss of 
control of the airplane.

DATES: This AD becomes effective on August 7, 2006.
    As of August 7, 2006, the Director of the Federal Register approved 
the incorporation by reference of certain publications listed in the 
regulation.

ADDRESSES: For service information identified in this AD, contact 
Raytheon Aircraft Company, P.O. Box 85, Wichita, Kansas 67201-0085; 
telephone: (800) 429-5372 or (316) 676-3140.
    To view the AD docket, go to the Docket Management Facility; U.S. 
Department of Transportation, 400 Seventh Street, SW., Nassif Building, 
Room PL-401, Washington, DC 20590-001 or on the Internet at <a href="http://dms.dot.gov">http://dms.dot.gov</a>. The docket number is FAA-2005-23319; Directorate 
Identifier 2005-CE-52-AD.

FOR FURTHER INFORMATION CONTACT: Steven E. Potter, Aerospace Engineer, 
Wichita Aircraft Certification Office, FAA, 1801 Airport Road, Wichita, 
Kansas 67209; telephone: (316) 946-4124; facsimile: (316) 946-4107.

SUPPLEMENTARY INFORMATION:

Discussion

    On January 31, 2006, we issued a proposal to amend part 39 of the 
Federal Aviation Regulations (14 CFR part 39) to include an AD that 
would apply to certain Raytheon 65, 90, 99, and 100 series airplanes. 
This proposal was published in the Federal Register as a notice of 
proposed rulemaking (NPRM) on February 6, 2006 (71 FR 6025). The NPRM 
proposed to supersede AD 92-07-05, Amendment 39-8201 (57 FR 8721, March 
12, 1992) and to add serial numbers LJ-1281 through LJ-1732 for the 
Model C90A airplanes in the applicability section. This AD will retain 
all the actions of AD 92-07-05 for inspecting and modifying the rudder 
trim tab for correct drainage provisions.

Comments

    We provided the public the opportunity to participate in developing 
this AD. We received no comments on the proposal or on the 
determination of the cost to the public.

Conclusion

    We have carefully reviewed the available data and determined that 
air safety and the public interest require adopting the AD as proposed 
except for minor editorial corrections. We have determined that these 
minor corrections:
    <bullet> Are consistent with the intent that was proposed in the 
NPRM for correcting the unsafe condition; and
    <bullet> Do not add any additional burden upon the public than was 
already proposed in the NPRM.

Costs of Compliance

    We estimate that this AD affects 2,407 airplanes in the U.S. 
registry.
    We estimate the following costs to do the inspection:

----------------------------------------------------------------------------------------------------------------
                                                            Total cost per
             Labor cost                    Parts cost          airplane         Total cost on U.S.  operators
----------------------------------------------------------------------------------------------------------------
1 work-hour x $80 = $80............  Not Applicable.......             $80  2,407 x $80 = $192,560.
----------------------------------------------------------------------------------------------------------------

    We estimate the following costs to do any necessary modification of 
the rudder trim tab to provide the correct drainage provisions that 
would be required based on the results of this inspection. We have no 
way of determining the number of airplanes that may need this 
modification:

------------------------------------------------------------------------
                                                          Total cost per
              Labor cost                   Parts cost        airplane
------------------------------------------------------------------------
1 work-hour x $80 = $80...............             $25             $105
------------------------------------------------------------------------


[[Page 36186]]

Authority for This Rulemaking

    Title 49 of the United States Code specifies the FAA's authority to 
issue rules on aviation safety. Subtitle I, section 106 describes the 
authority of the FAA Administrator. Subtitle VII, Aviation Programs, 
describes in more detail the scope of the agency's authority.
    We are issuing this rulemaking under the authority described in 
subtitle VII, part A, subpart III, section 44701, ``General 
requirements.'' Under that section, Congress charges the FAA with 
promoting safe flight of civil aircraft in air commerce by prescribing 
regulations for practices, methods, and procedures the Administrator 
finds necessary for safety in air commerce. This regulation is within 
the scope of that authority because it addresses an unsafe condition 
that is likely to exist or develop on products identified in this AD.

Regulatory Findings

    We have determined that this AD will not have federalism 
implications under Executive Order 13132. This AD will not have a 
substantial direct effect on the States, on the relationship between 
the national government and the States, or on the distribution of power 
and responsibilities among the various levels of government.
    For the reasons discussed above, I certify that this AD:
    1. Is not a ``significant regulatory action'' under Executive Order 
12866;
    2. Is not a ``significant rule'' under the DOT Regulatory Policies 
and Procedures (44 FR 11034, February 26, 1979); and
    3. Will not have a significant economic impact, positive or 
negative, on a substantial number of small entities under the criteria 
of the Regulatory Flexibility Act.
    We prepared a summary of the costs to comply with this AD (and 
other information as included in the Regulatory Evaluation) and placed 
it in the AD Docket. You may get a copy of this summary by sending a 
request to us at the address listed under ADDRESSES. Include ``Docket 
No. FAA-2005-23319; Directorate Identifier 2005-CE-52-AD'' in your 
request.

List of Subjects in 14 CFR Part 39

    Air transportation, Aircraft, Aviation safety, Incorporation by 
reference, Safety.

Adoption of the Amendment

0
Accordingly, under the authority delegated to me by the Administrator, 
the Federal Aviation Administration amends part 39 of the Federal 
Aviation Regulations (14 CFR part 39) as follows:

PART 39--AIRWORTHINESS DIRECTIVES

0
1. The authority citation for part 39 continues to read as follows:

    Authority: 49 U.S.C. 106(g), 40113, 44701.


Sec.  39.13  [Amended]

0
2. FAA amends Sec.  39.13 by removing Airworthiness Directive (AD) 92-
07-05, Amendment 39-8201 (57 FR 8721, March 12, 1992), and by adding 
the following new airworthiness directive:

2006-13-10 Raytheon Aircraft Company (Formerly Beech): Amendment 39-
14663; Docket No. FAA-2005-23319; Directorate Identifier 2005-CE-52-
AD.

Effective Date

    (a) This AD becomes effective on August 7, 2006.

Affected ADs

    (b) This AD supersedes AD 92-07-05; Amendment 39-8201.

Applicability

    (c) This AD affects the following airplane models and serial 
numbers that are certificated in any category:
    (1) Group 1 (maintains the actions from AD 92-07-05):

------------------------------------------------------------------------
                 Model                             Serial Nos.
------------------------------------------------------------------------
(i) 65-90, 65-A90, B90, C90, and C90A..  LJ-1 through LJ-1280.
(ii) E90...............................  LW-1 through LW-347.
(iii) 99, 99A, A99, A99A, B99, and C99.  U-1 through U-136 and U-146
                                          through U-239.
(iv) 100 and A100......................  B1 through B-94, B-100 through
                                          B-204, and B-206 through B247.
(v) B100...............................  BE-1 through BE-137.
(vi) 65-A90-1 (U-21A, JU-21A, RU-21D,    LM-1 through LM-141.
 RU-21H, RU-21A, U-21G).
(vii) 65-A90-2 (RU-21B)................  LS-1, LS-2, and LS-3.
(viii) 65-A90-3 (RU-21C)...............  LT-1 and LT-2.
(ix) 65-A90-4 (RU-21EA, U-21H, RU-21H).  LU-1 through LU-16.
(x) H90 (T-44A)........................  LL-1 through LL-61.
(xi) 99A (FACH)........................  U-137 through U-145.
(xii) A100 (U-21F).....................  B95 through B-99.
------------------------------------------------------------------------

    (2) Group 2: Model C90A, serial numbers LJ-1281 through LJ-1732.

Unsafe Condition

    (d) This AD results from receiving and evaluating new service 
information that requires the actions of AD 92-07-05 for the added 
serial numbers LJ-1281 through LJ-1732 for the Model C90A airplanes. 
The actions specified in this AD are intended to prevent water 
accumulation in the rudder trim tab, which could result in a change 
in the mass properties and possibly a lower flutter speed of the 
airplane. A lower airplane flutter speed could result in failure and 
loss of control of the airplane.

Compliance

    (e) To address this problem, you must do the following:

------------------------------------------------------------------------
           Actions                 Compliance            Procedures
------------------------------------------------------------------------
(1) For Group 1 Airplanes:    Within 150 hours      Follow Beech Service
 Inspect the rudder trim tab   time-in-service       Bulletin No. 2365,
 for proper moisture           (TIS) after April     Revision 1, dated
 drainage provisions.          30, 1992 (the         December 1991.
                               effective date of
                               AD 92-07-05),
                               unless already done.
(2) For Group 1 Airplanes:    Before further        Follow Beech Service
 If the correct drainage       flight after the      Bulletin No. 2365,
 provisions do not exist,      inspection required   Revision 1, dated
 modify the rudder trim tab.   by paragraph (e)(1)   December 1991.
                               of this AD.
(3) For Group 2 Airplanes:    Within 150 hours TIS  Follow Raytheon
 Inspect the rudder trim tab   after August 7,       Aircraft Company
 for proper moisture           2006 (the effective   Service Bulletin
 drainage provisions.          date of this AD),     No. SB 55-2365,
                               unless already done.  Revision 2, Issued:
                                                     January 1991,
                                                     Revised: October
                                                     2005.

[[Page 36187]]

 
(4) For Group 2 Airplanes:    Before further        Follow Raytheon
 If the correct drainage       flight after the      Aircraft Company
 provisions do not exist,      inspection required   Service Bulletin
 modify the rudder trim tab.   by paragraph (e)(3)   No. SB 55-2365,
                               of this AD.           Revision 2, Issued:
                                                     January 1991,
                                                     Revised: October
                                                     2005.
------------------------------------------------------------------------

Alternative Methods of Compliance (AMOCs)

    (f) The Manager, Wichita Aircraft Certification Office (ACO), 
FAA, ATTN: Steven E. Potter, Aerospace Engineer, Wichita ACO, FAA, 
1801 Airport Road, Wichita, Kansas 67209; telephone: (316) 946-4124; 
facsimile: (316) 946-4107, has the authority to approve AMOCs for 
this AD, if requested using the procedures found in 14 CFR 39.19.
    (g) AMOCs approved for AD 92-07-05 are not approved for this AD.

Material Incorporated by Reference

    (h) You must do the actions required by this AD following the 
instructions in Beechcraft Mandatory Service Bulletin No. 2365, 
Revision 1, dated December 1991, and Raytheon Aircraft Company 
Service Bulletin No. SB 55-2365, Revision 2, Issued: January 1991, 
Revised: October 2005. The Director of the Federal Register approved 
the incorporation by reference of these service bulletins in 
accordance with 5 U.S.C. 552(a) and 1 CFR part 51. To get a copy of 
this service information, contact Raytheon Aircraft Company, P.O. 
Box 85, Wichita, Kansas 67201-0085; telephone: (800) 429-5372 or 
(316) 676-3140. To review copies of this service information, go to 
the National Archives and Records Administration (NARA). For 
information on the availability of this material at NARA, go to: 
<a href="http://www.archives.gov/6federal_register/code_of_federal_regulations/ibr_locations.html">http://www.archives.gov/6federal_register/code_of_federal_regulations/ibr_locations.html</a> or call (202) 741-6030. To view the 
AD docket, go to the Docket Management Facility; U.S. Department of 
Transportation, 400 Seventh Street, SW., Nassif Building, Room PL-
401, Washington, DC 20590-001 or on the Internet at <a href="http://dms.dot.gov">http://dms.dot.gov</a>. The docket number is FAA-2005-23319; Directorate 
Identifier 2005-CE-52-AD.

    Issued in Kansas City, Missouri, on June 13, 2006.
James E. Jackson,
Acting Manager, Small Airplane Directorate, Aircraft Certification 
Service.
[FR Doc. 06-5586 Filed 6-23-06; 8:45 am]
BILLING CODE 4910-13-P