AD 2001-12-08

[Federal Register Volume 66, Number 116 (Friday, June 15, 2001)]
[Rules and Regulations]
[Pages 32531-32533]
From the Federal Register Online via the Government Publishing Office [<a href="http://www.gpo.gov">www.gpo.gov</a>]
[FR Doc No: 01-14723]


-----------------------------------------------------------------------

DEPARTMENT OF TRANSPORTATION

Federal Aviation Administration

14 CFR Part 39

[Docket No. 2000-NM-116-AD; Amendment 39-12263; AD 2001-12-08]
RIN 2120-AA64


Airworthiness Directives; Boeing Model 767 Series Airplanes

AGENCY: Federal Aviation Administration, DOT.

ACTION: Final rule.

-----------------------------------------------------------------------

SUMMARY: This amendment adopts a new airworthiness directive (AD), 
applicable to certain Boeing Model 767 series airplanes, that requires 
removing the two existing escape ropes in the flight compartment; 
installing new escape ropes, bags, and placards; and replacing the 
nylon straps with new straps; as applicable. This action is necessary 
to ensure that flight crew members safely reach the ground from a 
flight compartment window in the event of an emergency evacuation. This 
action is intended to address the identified unsafe condition.

[[Page 32532]]


DATES: Effective July 20, 2001.
    The incorporation by reference of certain publications listed in 
the regulations is approved by the Director of the Federal Register as 
of July 20, 2001.

ADDRESSES: The service information referenced in this AD may be 
obtained from Boeing Commercial Airplane Group, P.O. Box 3707, Seattle, 
Washington 98124-2207. This information may be examined at the Federal 
Aviation Administration (FAA), Transport Airplane Directorate, Rules 
Docket, 1601 Lind Avenue, SW., Renton, Washington; or at the Office of 
the Federal Register, 800 North Capitol Street, NW., suite 700, 
Washington, DC.

FOR FURTHER INFORMATION CONTACT: Jim Cashdollar, Aerospace Engineer, 
Airframe Branch, ANM-120S, FAA, Seattle Aircraft Certification Office, 
1601 Lind Avenue, SW., Renton, Washington 98055-4056; telephone (425) 
227-2785; fax (425) 227-1181.

SUPPLEMENTARY INFORMATION: A proposal to amend part 39 of the Federal 
Aviation Regulations (14 CFR part 39) to include an airworthiness 
directive (AD) that is applicable to certain Boeing Model 767 series 
airplanes was published in the Federal Register on January 16, 2001 (66 
FR 3515). That action proposed to require removing the two existing 
escape ropes in the flight compartment; installing new escape ropes, 
bags, and placards; and replacing the nylon straps with new straps; as 
applicable.

Comments Received

    Interested persons have been afforded an opportunity to participate 
in the making of this amendment. Due consideration has been given to 
the single comment received.
    The commenter supports the proposed rule.

Conclusion

    After careful review of the available data, including the comment 
noted above, the FAA has determined that air safety and the public 
interest require the adoption of the rule as proposed.

Cost Impact

    There are approximately 321 Model 767 series airplanes of the 
affected design in the worldwide fleet. The FAA estimates that 136 
airplanes of U.S. registry will be affected by this AD, that it will 
take approximately 1 work hour per airplane to accomplish the required 
actions, and that the average labor rate is $60 per work hour. Required 
parts will cost approximately $4,718 per airplane. Based on these 
figures, the cost impact of the AD on U.S. operators is estimated to be 
$649,808, or $4,778 per airplane.
    The cost impact figure discussed above is based on assumptions that 
no operator has yet accomplished any of the requirements of this AD 
action, and that no operator would accomplish those actions in the 
future if this AD were not adopted. The cost impact figures discussed 
in AD rulemaking actions represent only the time necessary to perform 
the specific actions actually required by the AD. These figures 
typically do not include incidental costs, such as the time required to 
gain access and close up, planning time, or time necessitated by other 
administrative actions.

Regulatory Impact

    The regulations adopted herein will not have a substantial direct 
effect on the States, on the relationship between the national 
Government and the States, or on the distribution of power and 
responsibilities among the various levels of government. Therefore, it 
is determined that this final rule does not have federalism 
implications under Executive Order 13132.
    For the reasons discussed above, I certify that this action (1) is 
not a ``significant regulatory action'' under Executive Order 12866; 
(2) is not a ``significant rule'' under DOT Regulatory Policies and 
Procedures (44 FR 11034, February 26, 1979); and (3) will not have a 
significant economic impact, positive or negative, on a substantial 
number of small entities under the criteria of the Regulatory 
Flexibility Act. A final evaluation has been prepared for this action 
and it is contained in the Rules Docket. A copy of it may be obtained 
from the Rules Docket at the location provided under the caption 
ADDRESSES.

List of Subjects in 14 CFR Part 39

    Air transportation, Aircraft, Aviation safety, Incorporation by 
reference, Safety.

Adoption of the Amendment

    Accordingly, pursuant to the authority delegated to me by the 
Administrator, the Federal Aviation Administration amends part 39 of 
the Federal Aviation Regulations (14 CFR part 39) as follows:

PART 39--AIRWORTHINESS DIRECTIVES

    1. The authority citation for part 39 continues to read as follows:

    Authority: 49 U.S.C. 106(g), 40113, 44701.


Sec. 39.13  [Amended]

    2. Section 39.13 is amended by adding the following new 
airworthiness directive:

2001-12-08  Boeing: Amendment 39-12263. Docket 2000-NM-116-AD.

    Applicability: Model 767 series airplanes, as listed in Boeing 
Alert Service Bulletin 767-25A0265, dated May 27, 1999; certificated 
in any category.

    Note 1: This AD applies to each airplane identified in the 
preceding applicability provision, regardless of whether it has been 
modified, altered, or repaired in the area subject to the 
requirements of this AD. For airplanes that have been modified, 
altered, or repaired so that the performance of the requirements of 
this AD is affected, the owner/operator must request approval for an 
alternative method of compliance in accordance with paragraph (b) of 
this AD. The request should include an assessment of the effect of 
the modification, alteration, or repair on the unsafe condition 
addressed by this AD; and, if the unsafe condition has not been 
eliminated, the request should include specific proposed actions to 
address it.

    Compliance: Required as indicated, unless accomplished 
previously.
    To ensure that flight crew members safely reach the ground from 
a flight compartment window in the event of an emergency evacuation, 
accomplish the following:
    Replacement
    (a) Within 18 months after the effective date of this AD, do the 
actions specified in paragraphs (a)(1) and (a)(2) of this AD, as 
applicable, per Boeing Alert Service Bulletin 767-25A0265, dated May 
27, 1999.
    (1) For all airplanes: Remove the two existing escape ropes and 
install new escape ropes, bags, and placards, as applicable, in the 
flight compartment.
    (2) For airplanes having serial numbers 1 through 107 inclusive; 
on which Boeing Service Bulletin 767-25-0149, dated March 7, 1991 
has been accomplished; or on which neither Boeing Service Bulletin 
767-25-0149, dated March 7, 1991, nor 767-25A0242, dated October 31, 
1996, has been accomplished: Replace the nylon straps with new 
straps.

Alternative Methods of Compliance

    (b) An alternative method of compliance or adjustment of the 
compliance time that provides an acceptable level of safety may be 
used if approved by the Manager, Seattle Aircraft Certification 
Office (ACO), FAA. Operators shall submit their requests through an 
appropriate FAA Principal Maintenance Inspector, who may add 
comments and then send it to the Manager, Seattle ACO.

    Note 2: Information concerning the existence of approved 
alternative methods of compliance with this AD, if any, may be 
obtained from the Seattle ACO.

Special Flight Permits

    (c) Special flight permits may be issued in accordance with 
sections 21.197 and 21.199 of the Federal Aviation Regulations (14 
CFR 21.197 and 21.199) to operate the airplane to a location where 
the requirements of this AD can be accomplished.

[[Page 32533]]

Incorporation by Reference

    (d) The actions shall be done in accordance with Boeing Alert 
Service Bulletin 767-25A0265, dated May 27, 1999. This incorporation 
by reference was approved by the Director of the Federal Register in 
accordance with 5 U.S.C. 552(a) and 1 CFR part 51. Copies may be 
obtained from Boeing Commercial Airplane Group, P.O. Box 3707, 
Seattle, Washington 98124-2207. Copies may be inspected at the FAA, 
Transport Airplane Directorate, 1601 Lind Avenue, SW., Renton, 
Washington; or at the Office of the Federal Register, 800 North 
Capitol Street, NW., suite 700, Washington, DC.

Effective Date

    (e) This amendment becomes effective on July 20, 2001.

    Issued in Renton, Washington, on June 6, 2001.
Donald L. Riggin,
Acting Manager, Transport Airplane Directorate, Aircraft Certification 
Service.
[FR Doc. 01-14723 Filed 6-14-01; 8:45 am]
BILLING CODE 4910-13-U