AD 2000-24-13

[Federal Register Volume 65, Number 233 (Monday, December 4, 2000)]
[Rules and Regulations]
[Pages 75616-75618]
From the Federal Register Online via the Government Publishing Office [<a href="http://www.gpo.gov">www.gpo.gov</a>]
[FR Doc No: 00-30438]


-----------------------------------------------------------------------

DEPARTMENT OF TRANSPORTATION

Federal Aviation Administration

14 CFR Part 39

[Docket No. 2000-NM-34-AD; Amendment 39-12020; AD 2000-24-13]
RIN 2120-AA64


Airworthiness Directives; McDonnell Douglas Model MD-11 Series 
Airplanes

AGENCY: Federal Aviation Administration, DOT.

ACTION: Final rule.

-----------------------------------------------------------------------

SUMMARY: This amendment adopts a new airworthiness directive (AD), 
applicable to certain McDonnell Douglas Model MD-11 series airplanes, 
that requires replacing the ground support bracket(s); and rerouting 
the ground cables of the galley external power and main external power, 
or ground cables of the main external power; as applicable. This action 
is necessary to prevent arcing and heat damage to the attachment points 
of the main external and galley power

[[Page 75617]]

receptacle ground wire, insulation blankets outboard and aft of the 
receptacle area, and adjacent power cables, which could result in smoke 
and fire in the forward cargo compartment. This action is intended to 
address the identified unsafe condition.

DATES: Effective January 8, 2001.
    The incorporation by reference of certain publications listed in 
the regulations is approved by the Director of the Federal Register as 
of January 8, 2001.

ADDRESSES: The service information referenced in this AD may be 
obtained from Boeing Commercial Aircraft Group, Long Beach Division, 
3855 Lakewood Boulevard, Long Beach, California 90846, Attention: 
Technical Publications Business Administration, Dept. C1-L51 (2-60). 
This information may be examined at the Federal Aviation Administration 
(FAA), Transport Airplane Directorate, Rules Docket, 1601 Lind Avenue, 
SW., Renton, Washington; or at the the FAA, Los Angeles Aircraft 
Certification Office, 3960 Paramount Boulevard, Lakewood, California; 
or at the Office of the Federal Register, 800 North Capitol Street, 
NW., suite 700, Washington, DC.

FOR FURTHER INFORMATION CONTACT: Brett Portwood, Aerospace Engineer, 
Systems and Equipment Branch, ANM-130L, FAA, Los Angeles Aircraft 
Certification Office, 3960 Paramount Boulevard, Lakewood, California 
90712-4137; telephone (562) 627-5350; fax (562) 627-5210.

SUPPLEMENTARY INFORMATION: A proposal to amend part 39 of the Federal 
Aviation Regulations (14 CFR part 39) to include an airworthiness 
directive (AD) that is applicable to certain McDonnell Douglas Model 
MD-11 series airplanes was published in the Federal Register on July 
27, 2000 (65 FR 46214). That action proposed to require replacing the 
ground support bracket(s); and rerouting the ground cables of the 
galley external power and main external power, or ground cables of the 
main external power; as applicable.

Comments

    Interested persons have been afforded an opportunity to participate 
in the making of this amendment. Due consideration has been given to 
the single comment received.
    The commenter states that there is a typographical error in the 
service bulletin citation in paragraph (a) of the proposed rule. The 
FAA concurs. Paragraph (a) of the proposed rule incorrectly references 
McDonnell Douglas Alert Service Bulletin MD11-24A128, dated April 3, 
2000, as the appropriate source of service information for the 
accomplishment of the actions required by paragraphs (a)(1) and (a)(2) 
of the AD. The correct reference is McDonnell Douglas Alert Service 
Bulletin MD11-24A138, dated April 3, 2000. Paragraph (a) of this AD has 
been changed accordingly.

Conclusion

    After careful review of the available data, including the comment 
noted above, the FAA has determined that air safety and the public 
interest require the adoption of the rule with the change previously 
described. The FAA has determined that this change will neither 
increase the economic burden on any operator nor increase the scope of 
the AD.

Cost Impact

    There are approximately 149 Model MD-11 series airplanes of the 
affected design in the worldwide fleet. The FAA estimates that 55 
airplanes of U.S. registry will be affected by this AD, that it will 
take approximately between 1 (for Group 1 airplanes) and 2 (for Group 2 
airplanes) work hours per airplane to accomplish the required actions, 
and that the average labor rate is $60 per work hour. Required parts 
will cost approximately $337 (for Group 1 airplanes) or $647 (for Group 
2 airplanes) per airplane. Based on these figures, the cost impact of 
the AD on U.S. operators is estimated to be $21,835, or $397 per 
airplane (for Group 1 airplanes); or $42,185, or $767 per airplane (for 
Group 2 airplanes).
    The cost impact figures discussed above are based on assumptions 
that no operator has yet accomplished any of the requirements of this 
AD action, and that no operator would accomplish those actions in the 
future if this AD were not adopted. The cost impact figures discussed 
in AD rulemaking actions represent only the time necessary to perform 
the specific actions actually required by the AD. These figures 
typically do not include incidental costs, such as the time required to 
gain access and close up, planning time, or time necessitated by other 
administrative actions.

Regulatory Impact

    The regulations adopted herein will not have a substantial direct 
effect on the States, on the relationship between the national 
Government and the States, or on the distribution of power and 
responsibilities among the various levels of government. Therefore, it 
is determined that this final rule does not have federalism 
implications under Executive Order 13132.
    For the reasons discussed above, I certify that this action (1) is 
not a ``significant regulatory action'' under Executive Order 12866; 
(2) is not a ``significant rule'' under DOT Regulatory Policies and 
Procedures (44 FR 11034, February 26, 1979); and (3) will not have a 
significant economic impact, positive or negative, on a substantial 
number of small entities under the criteria of the Regulatory 
Flexibility Act. A final evaluation has been prepared for this action 
and it is contained in the Rules Docket. A copy of it may be obtained 
from the Rules Docket at the location provided under the caption 
ADDRESSES.

List of Subjects in 14 CFR Part 39

    Air transportation, Aircraft, Aviation safety, Incorporation by 
reference, Safety.

Adoption of the Amendment

    Accordingly, pursuant to the authority delegated to me by the 
Administrator, the Federal Aviation Administration amends part 39 of 
the Federal Aviation Regulations (14 CFR part 39) as follows:

PART 39--AIRWORTHINESS DIRECTIVES

    1. The authority citation for part 39 continues to read as follows:

    Authority: 49 U.S.C. 106(g), 40113, 44701.


Sec. 39.13  [Amended]

    2. Section 39.13 is amended by adding the following new 
airworthiness directive:

2000-24-13 McDonnell Douglas: Amendment 39-12020. Docket 2000-NM-34-
AD.

    Applicability: Model MD-11 series airplanes, as listed in 
McDonnell Douglas Alert Service Bulletin MD11-24A138, dated April 3, 
2000; certificated in any category.

    Note 1: This AD applies to each airplane identified in the 
preceding applicability provision, regardless of whether it has been 
modified, altered, or repaired in the area subject to the 
requirements of this AD. For airplanes that have been modified, 
altered, or repaired so that the performance of the requirements of 
this AD is affected, the owner/operator must request approval for an 
alternative method of compliance in accordance with paragraph (b) of 
this AD. The request should include an assessment of the effect of 
the modification, alteration, or repair on the unsafe condition 
addressed by this AD; and, if the unsafe condition has not been 
eliminated, the request should include specific proposed actions to 
address it.

    Compliance: Required as indicated, unless accomplished 
previously.
    To prevent arcing and heat damage to the attachment points of 
the main external and galley power receptacle ground wire,

[[Page 75618]]

insulation blankets outboard and aft of the receptacle area, and 
adjacent power cables, which could result in smoke and fire in the 
forward cargo compartment, accomplish the following:

Replacement and Reroute

    (a) Within 12 months after the effective date of this AD, 
accomplish the actions specified in paragraph (a)(1) or (a)(2) of 
this AD, as applicable, in accordance with McDonnell Douglas Alert 
Service Bulletin MD11-24A138, dated April 3, 2000.
    (1) For Group 1 airplanes listed in the service bulletin: 
Replace the ground support brackets with new brackets and reroute 
the ground cables of the galley external power and main external 
power.
    (2) For Group 2 airplanes listed in the service bulletin: 
Replace the ground support bracket and reroute the ground cables of 
the main external power.

Alternative Methods of Compliance

    (b) An alternative method of compliance or adjustment of the 
compliance time that provides an acceptable level of safety may be 
used if approved by the Manager, Los Angeles Aircraft Certification 
Office (ACO), FAA. Operators shall submit their requests through an 
appropriate FAA Principal Maintenance Inspector, who may add 
comments and then send it to the Manager, Los Angeles ACO.

    Note 2: Information concerning the existence of approved 
alternative methods of compliance with this AD, if any, may be 
obtained from the Los Angeles ACO.

Special Flight Permit

    (c) Special flight permits may be issued in accordance with 
sections 21.197 and 21.199 of the Federal Aviation Regulations (14 
CFR 21.197 and 21.199) to operate the airplane to a location where 
the requirements of this AD can be accomplished.

Incorporation by Reference

    (d) The actions shall be done in accordance with McDonnell 
Douglas Alert Service Bulletin MD11-24A138, dated April 3, 2000. 
This incorporation by reference was approved by the Director of the 
Federal Register in accordance with 5 U.S.C. 552(a) and 1 CFR part 
51. Copies may be obtained from Boeing Commercial Aircraft Group, 
Long Beach Division, 3855 Lakewood Boulevard, Long Beach, California 
90846, Attention: Technical Publications Business Administration, 
Dept. C1-L51 (2-60). Copies may be inspected at the FAA, Transport 
Airplane Directorate, 1601 Lind Avenue, SW., Renton, Washington; or 
at the the FAA, Los Angeles Aircraft Certification Office, 3960 
Paramount Boulevard, Lakewood, California; or at the Office of the 
Federal Register, 800 North Capitol Street, NW., suite 700, 
Washington, DC.

Effective Date

    (e) This amendment becomes effective on January 8, 2001.

    Issued in Renton, Washington, on November 22, 2000.
Donald L. Riggin,
Acting Manager, Transport Airplane Directorate, Aircraft Certification 
Service.
[FR Doc. 00-30438 Filed 12-1-00; 8:45 am]
BILLING CODE 4910-13-P