AD 2000-15-14

[Federal Register Volume 65, Number 153 (Tuesday, August 8, 2000)]
[Rules and Regulations]
[Pages 48362-48364]
From the Federal Register Online via the Government Publishing Office [<a href="http://www.gpo.gov">www.gpo.gov</a>]
[FR Doc No: 00-19814]


-----------------------------------------------------------------------

DEPARTMENT OF TRANSPORTATION

Federal Aviation Administration

14 CFR Part 39

[Docket No. 2000-NM-219-AD; Amendment 39-11846; AD 2000-15-14]
RIN 2120-AA64


Airworthiness Directives; McDonnell Douglas Model MD-11 Series 
Airplanes

AGENCY: Federal Aviation Administration, DOT.

ACTION: Final rule; request for comments.

-----------------------------------------------------------------------

SUMMARY: This amendment adopts a new airworthiness directive (AD) that 
is applicable to certain McDonnell Douglas Model MD-11 series 
airplanes. This action requires repetitive inspections to verify 
operation of the

[[Page 48363]]

remote control circuit breakers (RCCB) of the alternating current (AC) 
cabin bus switch, and replacement of any discrepant RCCB with a new 
RCCB. This action is necessary to prevent propagation of smoke and 
fumes in the cockpit and passenger cabin due to an inoperable RCCB of 
the AC cabin bus switch during smoke and fume isolation procedures. 
This action is intended to address the identified unsafe condition.

DATES: Effective August 23, 2000.
    The incorporation by reference of certain publications listed in 
the regulations is approved by the Director of the Federal Register as 
of August 23, 2000.
    Comments for inclusion in the Rules Docket must be received on or 
before October 10, 2000.

ADDRESSES: Submit comments in triplicate to the Federal Aviation 
Administration (FAA), Transport Airplane Directorate, ANM-114, 
Attention: Rules Docket No. 2000-NM-219-AD, 1601 Lind Avenue, SW., 
Renton, Washington 98055-4056. Comments may be inspected at this 
location between 9 a.m. and 3 p.m., Monday through Friday, except 
Federal holidays. Comments may be submitted via fax to (425) 227-1232. 
Comments may also be sent via the Internet using the following address: 
<a href="/cdn-cgi/l/email-protection#fdc4d09c9390d0949c8f9e929090989389bd9b9c9cd39a928b"><span class="__cf_email__" data-cfemail="7c45511d121151151d0e1f1311111912083c1a1d1d521b130a">[email&#160;protected]</span></a>. Comments sent via fax or the Internet must 
contain ``Docket No. 2000-NM-219-AD'' in the subject line and need not 
be submitted in triplicate. Comments sent via the Internet as attached 
electronic files must be formatted in Microsoft Word 97 for Windows or 
ASCII text.
    The service information referenced in this AD may be obtained from 
Boeing Commercial Aircraft Group, Long Beach Division, 3855 Lakewood 
Boulevard, Long Beach, California 90846, Attention: Technical 
Publications Business Administration, Dept. C1-L51 (2-60). This 
information may be examined at the FAA, Transport Airplane Directorate, 
1601 Lind Avenue, SW., Renton, Washington; or at the FAA, Transport 
Airplane Directorate, Los Angeles Aircraft Certification Office, 3960 
Paramount Boulevard, Lakewood, California; or at the Office of the 
Federal Register, 800 North Capitol Street, NW., suite 700, Washington, 
DC.

FOR FURTHER INFORMATION CONTACT: Brett Portwood, Aerospace Engineer, 
Systems and Equipment Branch, ANM-130L, FAA, Transport Airplane 
Directorate, Los Angeles Aircraft Certification Office, 3960 Paramount 
Boulevard, Lakewood, California 90712-4137; telephone (562) 627-5350; 
fax (562) 627-5210.

SUPPLEMENTARY INFORMATION: As part of its practice of re-examining all 
aspects of the service experience of a particular aircraft whenever an 
accident occurs, the FAA has become aware of incidents in which certain 
remote control circuit breakers (RCCB) of the alternating current (AC) 
cabin bus switch failed when the switch was pushed to the ``OFF'' 
position. These incidents occurred on McDonnell Douglas Model MD-11 
series airplanes. Investigation revealed that an inoperable RCCB may 
not trip open (disconnects cabin bus loads) when commanded during smoke 
and fume isolation procedures. Even though an RCCB may be inoperable, 
the cabin bus ``OFF'' overhead switch light could still illuminate, 
which could mislead the flightcrew that all cabin buses have been 
deenergized. An inoperable RCCB of the AC cabin bus switch during smoke 
and fume isolation procedures, if not corrected, could result in the 
propagation of smoke and fumes in the cockpit and passenger cabin.
    These incidents are not considered to be related to an accident 
that occurred off the coast of Nova Scotia involving a McDonnell 
Douglas Model MD-11 series airplane. The cause of that accident is 
still under investigation.

Other Related Rulemaking

    The FAA, in conjunction with Boeing and operators of Model MD-11 
series airplanes, is continuing to review all aspects of the service 
history of those airplanes to identify potential unsafe conditions and 
to take appropriate corrective actions. This airworthiness directive 
(AD) is one of a series of actions identified during that process. The 
process is continuing and the FAA may consider additional rulemaking 
actions as further results of the review become available.

Explanation of Relevant Service Information

    The FAA has reviewed and approved Boeing Alert Service Bulletin 
MD11-24A181, dated June 27, 2000, which describes procedures for 
repetitive inspections to verify operation of the RCCB's of the AC 
cabin bus switch, and replacement of any discrepant RCCB with a new 
RCCB.

Explanation of the Requirements of the Rule

    Since an unsafe condition has been identified that is likely to 
exist or develop on other McDonnell Douglas Model MD-11 series 
airplanes of the same type design, this AD is being issued to prevent 
propagation of smoke and fumes in the cockpit and passenger cabin due 
to an inoperable RCCB during smoke and fume isolation procedures. This 
AD requires accomplishment of the actions specified in the service 
bulletin described previously.

Interim Action

    This is considered to be interim action until final action is 
identified, at which time the FAA may consider further rulemaking.

Determination of Rule's Effective Date

    Since a situation exists that requires the immediate adoption of 
this regulation, it is found that notice and opportunity for prior 
public comment hereon are impracticable, and that good cause exists for 
making this amendment effective in less than 30 days.

Comments Invited

    Although this action is in the form of a final rule that involves 
requirements affecting flight safety and, thus, was not preceded by 
notice and an opportunity for public comment, comments are invited on 
this rule. Interested persons are invited to comment on this rule by 
submitting such written data, views, or arguments as they may desire. 
Communications shall identify the Rules Docket number and be submitted 
in triplicate to the address specified under the caption ADDRESSES. All 
communications received on or before the closing date for comments will 
be considered, and this rule may be amended in light of the comments 
received. Factual information that supports the commenter's ideas and 
suggestions is extremely helpful in evaluating the effectiveness of the 
AD action and determining whether additional rulemaking action would be 
needed.
    Submit comments using the following format:
    <bullet> Organize comments issue-by-issue. For example, discuss a 
request to change the compliance time and a request to change the 
service bulletin reference as two separate issues.
    <bullet> For each issue, state what specific change to the AD is 
being requested.
    <bullet> Include justification (e.g., reasons or data) for each 
request.
    Comments are specifically invited on the overall regulatory, 
economic, environmental, and energy aspects of the rule that might 
suggest a need to modify the rule. All comments submitted will be 
available, both before and after the closing date for comments, in the 
Rules Docket for examination by interested persons. A report that 
summarizes each FAA-public contact

[[Page 48364]]

concerned with the substance of this AD will be filed in the Rules 
Docket.
    Commenters wishing the FAA to acknowledge receipt of their comments 
submitted in response to this rule must submit a self-addressed, 
stamped postcard on which the following statement is made: ``Comments 
to Docket Number 2000-NM-219-AD.'' The postcard will be date stamped 
and returned to the commenter.

Regulatory Impact

    The regulations adopted herein will not have a substantial direct 
effect on the States, on the relationship between the national 
Government and the States, or on the distribution of power and 
responsibilities among the various levels of government. Therefore, it 
is determined that this final rule does not have federalism 
implications under Executive Order 13132.
    The FAA has determined that this regulation is an emergency 
regulation that must be issued immediately to correct an unsafe 
condition in aircraft, and that it is not a ``significant regulatory 
action'' under Executive Order 12866. It has been determined further 
that this action involves an emergency regulation under DOT Regulatory 
Policies and Procedures (44 FR 11034, February 26, 1979). If it is 
determined that this emergency regulation otherwise would be 
significant under DOT Regulatory Policies and Procedures, a final 
regulatory evaluation will be prepared and placed in the Rules Docket. 
A copy of it, if filed, may be obtained from the Rules Docket at the 
location provided under the caption ADDRESSES.

List of Subjects in 14 CFR Part 39

    Air transportation, Aircraft, Aviation safety, Incorporation by 
reference, Safety.

Adoption of the Amendment

    Accordingly, pursuant to the authority delegated to me by the 
Administrator, the Federal Aviation Administration amends part 39 of 
the Federal Aviation Regulations (14 CFR part 39) as follows:

PART 39--AIRWORTHINESS DIRECTIVES

    1. The authority citation for part 39 continues to read as follows:

    Authority: 49 U.S.C. 106(g), 40113, 44701.


Sec. 39.13  [Amended]

    2. Section 39.13 is amended by adding the following new 
airworthiness directive:

2000-15-14  McDonnell Douglas: Amendment 39-11846. Docket 2000-NM-
219-AD.
    Applicability: Model MD-11 series airplanes, as listed in Boeing 
Alert Service Bulletin MD11-24A181, dated June 27, 2000; 
certificated in any category.

    Note 1: This AD applies to each airplane identified in the 
preceding applicability provision, regardless of whether it has been 
modified, altered, or repaired in the area subject to the 
requirements of this AD. For airplanes that have been modified, 
altered, or repaired so that the performance of the requirements of 
this AD is affected, the owner/operator must request approval for an 
alternative method of compliance in accordance with paragraph (b) of 
this AD. The request should include an assessment of the effect of 
the modification, alteration, or repair on the unsafe condition 
addressed by this AD; and, if the unsafe condition has not been 
eliminated, the request should include specific proposed actions to 
address it.

    Compliance: Required as indicated, unless accomplished 
previously.
    To prevent propagation of smoke and fumes in the cockpit and 
passenger cabin due to an inoperable remote control circuit breaker 
(RCCB) of the alternating current (AC) cabin bus switch during smoke 
and fume isolation procedures, accomplish the following:

Inspection

    (a) Within 45 days after the effective date of this AD, perform 
an inspection to verify operation of the RCCB's of the AC cabin bus 
switch in accordance with Boeing Alert Service Bulletin MD11-24A181, 
dated June 27, 2000.

Condition 1 (Proper Operation): Repetitive Inspections

    (1) If all RCCB's are operating properly, repeat the inspection 
thereafter at intervals not to exceed 700 flight hours.

Condition 2 (Improper Operation): Replacement and Repetitive 
Inspections

    (2) If any RCCB is NOT operating properly, prior to further 
flight, replace the failed RCCB with a new RCCB in accordance with 
the service bulletin. Repeat the inspection thereafter at intervals 
not to exceed 700 flight hours.

Alternative Methods of Compliance

    (b) An alternative method of compliance or adjustment of the 
compliance time that provides an acceptable level of safety may be 
used if approved by the Manager, Los Angeles Aircraft Certification 
Office (ACO), FAA, Transport Airplane Directorate. Operators shall 
submit their requests through an appropriate FAA Principal 
Maintenance Inspector, who may add comments and then send it to the 
Manager, Los Angeles ACO.

    Note 2: Information concerning the existence of approved 
alternative methods of compliance with this AD, if any, may be 
obtained from the Los Angeles ACO.

Special Flight Permits

    (c) Special flight permits may be issued in accordance with 
Secs. 21.197 and 21.199 of the Federal Aviation Regulations (14 CFR 
21.197 and 21.199) to operate the airplane to a location where the 
requirements of this AD can be accomplished.

Incorporation by Reference

    (d) The actions shall be done in accordance with Boeing Alert 
Service Bulletin MD11-24A181, dated June 27, 2000. This 
incorporation by reference was approved by the Director of the 
Federal Register in accordance with 5 U.S.C. 552(a) and 1 CFR part 
51.
    Copies may be obtained from Boeing Commercial Aircraft Group, 
Long Beach Division, 3855 Lakewood Boulevard, Long Beach, California 
90846, Attention: Technical Publications Business Administration, 
Dept. C1-L51 (2-60). Copies may be inspected at the FAA, Transport 
Airplane Directorate, 1601 Lind Avenue, SW., Renton, Washington; or 
at the FAA, Transport Airplane Directorate, Los Angeles Aircraft 
Certification Office, 3960 Paramount Boulevard, Lakewood, 
California; or at the Office of the Federal Register, 800 North 
Capitol Street, NW., suite 700, Washington, DC.

Effective Date

    (e) This amendment becomes effective on August 23, 2000.

    Issued in Renton, Washington, on July 28, 2000.
John J. Hickey,
Manager, Transport Airplane Directorate, Aircraft Certification 
Service.
[FR Doc. 00-19814 Filed 8-7-00; 8:45 am]
BILLING CODE 4910-13-U