AD 2000-07-17

[Federal Register Volume 65, Number 73 (Friday, April 14, 2000)]
[Rules and Regulations]
[Pages 20324-20326]
From the Federal Register Online via the Government Publishing Office [<a href="http://www.gpo.gov">www.gpo.gov</a>]
[FR Doc No: 00-8813]


-----------------------------------------------------------------------

DEPARTMENT OF TRANSPORTATION

Federal Aviation Administration

14 CFR Part 39

[Docket No. 99-NM-266-AD; Amendment 39-11671; AD 2000-07-17]
RIN 2120-AA64


Airworthiness Directives; McDonnell Douglas Model MD-11 Series 
Airplanes

AGENCY: Federal Aviation Administration, DOT.

ACTION: Final rule.

-----------------------------------------------------------------------

SUMMARY: This amendment adopts a new airworthiness directive (AD), 
applicable to certain McDonnell Douglas Model MD-11 series airplanes, 
that requires a general visual inspection to verify that the circuit 
breaker panel fully opens, follow-on inspections, and corrective 
actions, if necessary. This amendment is prompted by an incident of an 
operator not being able to fully open the observer's upper main circuit 
breaker panel due to a certain cable being too short. The actions 
specified by this AD are intended to ensure that the upper main circuit 
breaker panel opens fully. If the panel does not open fully, 
maintenance activities may be hindered and cause damage to the circuit 
breaker panel and wiring, which could result in electrical arcing and 
consequent smoke and fire in the flight compartment.

DATES: Effective May 19, 2000.
    The incorporation by reference of certain publications listed in 
the regulations is approved by the Director of the Federal Register as 
of May 19, 2000.

ADDRESSES: The service information referenced in this AD may be 
obtained from Boeing Commercial Aircraft Group, Long Beach Division, 
3855 Lakewood Boulevard, Long Beach, California 90846, Attention: 
Technical Publications Business Administration, Dept. C1-L51 (2-60). 
This information may be examined at the Federal Aviation Administration 
(FAA), Transport Airplane Directorate, Rules Docket, 1601 Lind Avenue, 
SW., Renton, Washington; or at the FAA, Transport Airplane Directorate, 
Los Angeles Aircraft Certification Office, 3960 Paramount Boulevard, 
Lakewood, California; or at the Office of the Federal Register, 800 
North Capitol Street, NW., suite 700, Washington, DC.

FOR FURTHER INFORMATION CONTACT: Brett Portwood, Aerospace Engineer, 
Systems and Equipment Branch, ANM-130L, FAA, Transport Airplane 
Directorate, Los Angeles Aircraft Certification Office, 3960 Paramount 
Boulevard, Lakewood, California 90712-4137; telephone (562) 627-5350; 
fax (562) 627-5210.

SUPPLEMENTARY INFORMATION: A proposal to amend part 39 of the Federal 
Aviation Regulations (14 CFR part 39) to include an airworthiness 
directive (AD) that is applicable to certain McDonnell Douglas Model 
MD-11 series airplanes was published in the Federal Register on 
February 1, 2000 (65 FR 4786). That action proposed to require a 
general visual inspection to verify that the circuit breaker panel 
fully opens, follow-on inspections, and corrective actions, if 
necessary.

Comments

    Interested persons have been afforded an opportunity to participate 
in the making of this amendment. Due consideration has been given to 
the single comment received.
    The commenter supports the proposed rule.

[[Page 20325]]

Conclusion

    After careful review of the available data, including the comment 
noted above, the FAA has determined that air safety and the public 
interest require the adoption of the rule as proposed.

Cost Impact

    There are approximately 161 airplanes of the affected design in the 
worldwide fleet. The FAA estimates that 66 airplanes of U.S. registry 
will be affected by this AD, that it will take approximately 1 work 
hour per airplane to accomplish the required inspections, and that the 
average labor rate is $60 per work hour. Based on these figures, the 
cost impact of the AD on U.S. operators is estimated to be $3,960, or 
$60 per airplane.
    The cost impact figure discussed above is based on assumptions that 
no operator has yet accomplished any of the requirements of this AD 
action, and that no operator would accomplish those actions in the 
future if this AD were not adopted.

Regulatory Impact

    The regulations adopted herein will not have a substantial direct 
effect on the States, on the relationship between the national 
Government and the States, or on the distribution of power and 
responsibilities among the various levels of government. Therefore, it 
is determined that this final rule does not have federalism 
implications under Executive Order 13132.
    For the reasons discussed above, I certify that this action (1) is 
not a ``significant regulatory action'' under Executive Order 12866; 
(2) is not a ``significant rule'' under DOT Regulatory Policies and 
Procedures (44 FR 11034, February 26, 1979); and (3) will not have a 
significant economic impact, positive or negative, on a substantial 
number of small entities under the criteria of the Regulatory 
Flexibility Act. A final evaluation has been prepared for this action 
and it is contained in the Rules Docket. A copy of it may be obtained 
from the Rules Docket at the location provided under the caption 
ADDRESSES.

List of Subjects in 14 CFR Part 39

    Air transportation, Aircraft, Aviation safety, Incorporation by 
reference, Safety.

Adoption of the Amendment

    Accordingly, pursuant to the authority delegated to me by the 
Administrator, the Federal Aviation Administration amends part 39 of 
the Federal Aviation Regulations (14 CFR part 39) as follows:

PART 39--AIRWORTHINESS DIRECTIVES

    1. The authority citation for part 39 continues to read as follows:

    Authority: 49 U.S.C. 106(g), 40113, 44701.


Sec. 39.13  [Amended]

    2. Section 39.13 is amended by adding the following new 
airworthiness directive:

2000-07-17 McDonnell Douglas: Amendment 39-11671. Docket 99-NM-266-
AD.

    Applicability: Model MD-11 series airplanes, as listed in 
McDonnell Douglas Alert Service Bulletin MD11-24A130, Revision 01, 
dated September 20, 1999; certificated in any category.

    Note 1: This AD applies to each airplane identified in the 
preceding applicability provision, regardless of whether it has been 
modified, altered, or repaired in the area subject to the 
requirements of this AD. For airplanes that have been modified, 
altered, or repaired so that the performance of the requirements of 
this AD is affected, the owner/operator must request approval for an 
alternative method of compliance in accordance with paragraph (e) of 
this AD. The request should include an assessment of the effect of 
the modification, alteration, or repair on the unsafe condition 
addressed by this AD; and, if the unsafe condition has not been 
eliminated, the request should include specific proposed actions to 
address it.

    Compliance: Required as indicated, unless accomplished 
previously.
    To ensure that the upper main circuit breaker panel opens fully, 
accomplish the following:

Inspection and a Follow-on Inspection

    (a) Within 6 months after the effective date of this AD, perform 
a general visual inspection to verify that the circuit breaker panel 
fully opens in accordance with McDonnell Douglas Alert Service 
Bulletin MD11-24A130, Revision 01, dated September 20, 1999.

    Note 2: For the purposes of this AD, a general visual inspection 
is defined as ``A visual examination of an interior or exterior 
area, installation, or assembly to detect obvious damage, failure, 
or irregularity. This level of inspection is made under normally 
available lighting conditions such as daylight, hangar lighting, 
flashlight, or drop-light, and may require removal or opening of 
access panels or doors. Stands, ladders, or platforms may be 
required to gain proximity to the area being checked.''

    (1) If the circuit breaker panel fully opens, prior to further 
flight, perform a detailed visual inspection of the wires between 
circuit breakers B1-213 and B1-300 to terminal strip S3-602 to 
detect chafing damage, in accordance with the service bulletin.
    (2) If the circuit breaker panel does not fully open, prior to 
further flight, perform a detailed visual inspection of the route 
path from circuit breakers B1-213 and B1-300 to terminal strip S3-
602 to detect chafing damage and to determine if the wire can be 
adjusted or if the wire must be replaced, in accordance with the 
service bulletin.

    Note 3: For the purposes of this AD, a detailed visual 
inspection is defined as: ``An intensive visual examination of a 
specific structural area, system, installation, or assembly to 
detect damage, failure, or irregularity. Available lighting is 
normally supplemented with a direct source of good lighting at 
intensity deemed appropriate by the inspector. Inspection aids such 
as mirror, magnifying lenses, etc., may be used. Surface cleaning 
and elaborate access procedures may be required.''

Corrective Actions

    (b) If any wire is found to need adjusting during the inspection 
required by paragraph (a)(2) of this AD, prior to further flight, 
adjust the wire in accordance with McDonnell Douglas Alert Service 
Bulletin MD11-24A130, Revision 01, dated September 20, 1999.
    (c) If any wire is found to need replacing during the inspection 
required by paragraph (a)(2) of this AD, prior to further flight, 
replace the wire with a new wire in accordance with McDonnell 
Douglas Alert Service Bulletin MD11-24A130, Revision 01, dated 
September 20, 1999.
    (d) If any chafing damage is found during the inspection 
required by paragraph (a)(1) or (a)(2) of this AD, prior to further 
flight, repair in accordance with McDonnell Douglas Alert Service 
Bulletin MD11-24A130, Revision 01, dated September 20, 1999.

Alternative Methods of Compliance

    (e) An alternative method of compliance or adjustment of the 
compliance time that provides an acceptable level of safety may be 
used if approved by the Manager, Los Angeles Aircraft Certification 
Office (ACO), FAA, Transport Airplane Directorate. Operators shall 
submit their requests through an appropriate FAA Principal 
Maintenance Inspector, who may add comments and then send it to the 
Manager, Los Angeles ACO.

    Note 4: Information concerning the existence of approved 
alternative methods of compliance with this AD, if any, may be 
obtained from the Los Angeles ACO.

Special Flight Permits

    (f) Special flight permits may be issued in accordance with 
Secs. 21.197 and 21.199 of the Federal Aviation Regulations (14 CFR 
21.197 and 21.199) to operate the airplane to a location where the 
requirements of this AD can be accomplished.

Incorporation by Reference

    (g) The actions shall be done in accordance with McDonnell 
Douglas Alert Service Bulletin MD11-24A130, Revision 01, dated 
September 20, 1999. This incorporation by reference was approved by 
the Director of the Federal Register in accordance with 5 U.S.C. 
552(a) and 1 CFR part 51. Copies may be obtained from Boeing 
Commercial Aircraft Group, Long Beach Division, 3855 Lakewood 
Boulevard, Long Beach, California 90846, Attention: Technical 
Publications Business Administration, Dept. C1-L51 (2-60). Copies 
may be inspected at the FAA, Transport Airplane Directorate, 1601 
Lind Avenue,

[[Page 20326]]

SW., Renton, Washington; or at the FAA, Transport Airplane 
Directorate, Los Angeles Aircraft Certification Office, 3960 
Paramount Boulevard, Lakewood, California; or at the Office of the 
Federal Register, 800 North Capitol Street, NW., suite 700, 
Washington, DC.
    (h) This amendment becomes effective on May 19, 2000.

    Issued in Renton, Washington, on April 4, 2000.
Donald L. Riggin,
Acting Manager, Transport Airplane Directorate, Aircraft Certification 
Service.
[FR Doc. 00-8813 Filed 4-13-00; 8:45 am]
BILLING CODE 4910-13-P